TB 9-2320-364-13&P-2
DOOR APPLIQUE REPLACEMENT - CONTINUED
0015 01
INSTALLATION - CONTINUED
WARN I N G
Use caution when using adhesives and sealants. Prolonged inhalation of vapors can cause lung irritation.
Contact with skin can cause dermatitis. Wear gloves and safety goggles and use product in a well-ventilated
area away from open flame. If ingested, keep individual calm and seek medical attention. DO NOT induce
vomiting. If contact with skin or eyes is made, flush thoroughly with water. Dispose of cleanup rags IAW
local policy and ordinances. Failure to follow this warning may cause injury to personnel.
N OT E
Apply thread adhesive to all bolts that thread into spacers.
2.
Apply thread adhesive to 20 bolts.
3.
Install two threaded spacers (12), washers (8), and bolts (7) on rear edge of door.
4.
Install four threaded spacers (11), washers (6), and bolts (5) above and below rear edge of window.
5.
Install six threaded spacers (10), washers (4), and bolts (3) above and below front edge of window.
6.
Install two threaded spacers (9), washers (1), and bolts (2) in front of window on door.
7.
Install two threaded spacers (28), washers (33), and bolts (34) on lower front edge of door.
8.
Install four threaded spacers (27), washers (31), and bolts (32) on bottom and middle of door.
WARN I N G
Use extreme caution when handling heavy parts. Provide adequate support and use assistance during proce-
dure. Ensure that any lifting device used is in good condition and of suitable load capacity. Keep clear of
heavy parts supported only by lifting device. Failure to follow this warning may cause injury or death to per-
sonnel.
N OT E
Door applique weighs 206 lb (94 kg).
9.
Attach sling and lifting device to top of door applique (13).
WARN I N G
Use caution when using adhesives and sealants. Prolonged inhalation of vapors can cause lung irritation.
Contact with skin can cause dermatitis. Wear gloves and safety goggles and use product in a well-ventilated
area away from open flame. If ingested, keep individual calm and seek medical attention. DO NOT induce
vomiting. If contact with skin or eyes is made, flush thoroughly with water. Dispose of cleanup rags IAW
local policy and ordinances. Failure to follow this warning may cause injury to personnel.
Change 1
0015 01-4
